https://scholars.lib.ntu.edu.tw/handle/123456789/63180
DC 欄位 | 值 | 語言 |
---|---|---|
dc.contributor | 劉懷勝 | zh-TW |
dc.contributor | 臺灣大學:化學工程學研究所 | zh-TW |
dc.contributor.author | 劉奕瑩 | zh-TW |
dc.contributor.author | Liu, Yi-Ying | en |
dc.creator | 劉奕瑩 | zh-TW |
dc.creator | Liu, Yi-Ying | en |
dc.date | 2008 | en |
dc.date.accessioned | 2010-06-30T06:11:32Z | - |
dc.date.accessioned | 2018-06-28T17:12:04Z | - |
dc.date.available | 2010-06-30T06:11:32Z | - |
dc.date.available | 2018-06-28T17:12:04Z | - |
dc.date.issued | 2008 | - |
dc.identifier.other | U0001-2507200812493800 | en |
dc.identifier.uri | http://ntur.lib.ntu.edu.tw//handle/246246/186922 | - |
dc.description.abstract | 本研究為錯流式旋轉填充床內的吸收程序來處理疏水性揮發有機物質。在過去的文獻中,吸收程序通常用水來處理親水性揮發有機物質,因為水是便宜、方便取得且有效的吸收劑。而在處理疏水性揮發有機物質時,水不再為適當的吸收劑;大部分的疏水性吸收劑為高黏度液體,會影響在填充床中的操作,造成溢流現象的產生,而錯流式旋轉填充床中以離心力取代重力,故可以突破高黏度的限制,吸收劑有更多的選擇,亦有更廣泛的氣液操作範圍。故本研究考慮了各疏水性吸收劑的亨利常數、黏度、價格、安全性,選擇了矽油用以吸收本實驗欲處理的疏水性揮發有機物質甲苯、二甲苯。 由實驗結果得之,隨著實驗的操作條作轉速、氣液流量增加,會使得質傳效果變好,而氣體進料濃度對於質傳效果的影響較小,質傳係數在這樣的濃度範圍下呈現一穩定值。而在低轉速(800 RPM)與低液體流量(240 mL/min)下,由直接觀察與實驗數據結果可得之,液體在填充床中有分佈不均勻的情形發生,會使得質傳效果下降。矽油在高液體流量與高轉速的操作下,對於甲苯、二甲苯有95%以上的吸收效果,達到可以直接排放的標準,是一安全且有效的處理疏水性揮發有機物質的化工程序。最後,將實驗所得到之質傳係數進行廻歸分析,得到一質傳係數經驗式如下,並且此經驗式可用來估算更廣泛液體黏度範圍中,在錯流式旋轉填充床中的質傳係數。 | zh-TW |
dc.description.abstract | In this study, absorption process that applies on treating hydrophobic volatile organic compounds (VOCs) in a cross-flow rotating packed bed (RPB) was investigated. In the literature of the past, it was usually used water to treated hydrophilic VOC on absorption process, because water was an inexpensive, available and effective absorber. When treating VOC, water is not more appropriate absorber. Most of hydrophobic absorbers have high viscosities to influence the operation in packed column and cause flooding. In RPB, it replaces gravity with centrifugal force, so it can be operated on a more extensive range of gas and liquid flow rate, and it does not restrict by high viscosity and choice more different absorber. In this study, we pondered over the Henry’s constant, viscosity, cost and safety of absorbers, and finally chose silicon oil to treated hydrophobic VOCs (toluene, xylene) on the absorption process. According to the experimental results, mass transfer efficiency increased with rotational speed, gas and liquid flow rate. However, the concentration of gas inlet had little influence on mass transfer efficiency. Mass transfer coefficient maintained a constant value on the range of those concentrations. At low rotational speed (800 RPM) and low liquid flow rate (240 mL/min), according to the experimental results and visual observation, there were no well liquid distribution in RPB; it made mass transfer efficiency decrease. Toluene and xylene were absorbed by silicon oil with high liquid flow rates and high rotational speeds; its efficiency exceeded 95% and achieved the standard of direct emission, so this was a safe and efficient chemical engineering process on treating hydrophobic VOCs. Finally, all experimental data were correlated into an empirical formula, and it estimates mass transfer coefficient on an extensive range of liquid viscosity in a cross-flow RPB. | en |
dc.description.tableofcontents | 摘要 Ibstract II目錄 V目錄 IX一章 緒論 1-1序言 1-2 研究目的 2二章 文獻回顧 3-1 超重力旋轉填充床系統簡介 3-1-1 超重力旋轉填充床的起源與構造 3-2 旋轉填充床的發展 6-3 旋轉填充床之特性 11-3-1 壓降 11-3-2 質傳係數 14-3-3 液體的流動型態 18-3-4 有效質傳界面積 20-4旋轉填充床的優點及應用 21-5 錯流式旋轉填充床之文獻回顧 24-6 其他揮發性有機物質的處理方法 28三章 實驗裝置、藥品與實驗方法 34-1 實驗裝置 34-2 實驗藥品及分析儀器 36-3 實驗方法 40-3-1 亨利常數的實驗方法 42-4 質傳係數的分析 44四章 結果與討論 49-1 吸收劑的選擇 49-2 以吸收百分比來評估質傳的效果 51-2-1 液體流量對吸收百分比的影響 52-2-2 氣體流量對吸收百分比的影響 52-2-3 轉速對於吸收百分比的影響 57-2-4 氣體進料濃度對於吸收百分比的影響 57-2-5 物理性質對於吸收百分比的影響 58-3 以質傳係數來評估質傳的效果 63-3-1 討論微體積的大小對於質傳係數的影響 63-3-2 液體流量對於質傳的影響 65-3-3 氣體流量對質傳效果的影響 65-3-4 轉速對於質傳效果的影響 70-3-5 氣體進料濃度對於質傳效果的影響 70-3-6 物理性質對於質傳的影響 71-4 旋轉填充床內各操作條件下的氣、液出口濃度比 76-5 液體循環操作系統對於質傳的影響 78-6 高黏度液體在錯流式旋轉填充床分佈情況對質傳影響 81-7 質傳係數之經驗式分析 82-7-1 其他錯流式旋轉填充床之比較 86-7-2 與逆流式旋轉填充床之比較 94-7-3 與傳統填充床之比較 97-8與其他VOCs處理法之比較 99五章 結論 101考文獻 104號說明 112錄 A 氣體、液體濃度與層析面積之校正曲線 115錄 B 球型度與填充物孔隙度之關係圖 119錄 C 揮發性有機物空氣污染管制及排放標準 120錄 D 疏水性揮發有機物質的實驗數據 121錄E Matlab 程式求總括氣膜體積質傳係數(Kga) 131錄F Matlab 程式來求KGa的廻歸經驗式 133錄G 以氣、液流量比預測吸收度 137錄 H 本實驗經驗式之討論 139錄 I 甲苯與矽油之間的亨利常數 141 | en |
dc.format.extent | 1437983 bytes | - |
dc.format.mimetype | application/pdf | - |
dc.language | zh-TW | en |
dc.language.iso | en_US | - |
dc.subject | 矽油 | zh-TW |
dc.subject | 甲苯 | zh-TW |
dc.subject | 二甲苯 | zh-TW |
dc.subject | 旋轉填充床 | zh-TW |
dc.subject | 疏水性揮發有機物質 | zh-TW |
dc.subject | 質傳 | zh-TW |
dc.subject | Rotating packed bed | en |
dc.subject | Hydrophobic VOCs | en |
dc.subject | toluene | en |
dc.subject | xylene | en |
dc.subject | Mass transfer | en |
dc.subject | silicon oil | en |
dc.title | 旋轉填充床之疏水性有機揮發物質的質傳研究 | zh-TW |
dc.title | Mass Transfer of Hydrophobic Volatile Organic Compounds In a Rotating Packed Bed | en |
dc.type | thesis | en |
dc.identifier.uri.fulltext | http://ntur.lib.ntu.edu.tw/bitstream/246246/186922/1/ntu-97-R95524082-1.pdf | - |
item.fulltext | with fulltext | - |
item.openairetype | thesis | - |
item.languageiso639-1 | en_US | - |
item.openairecristype | http://purl.org/coar/resource_type/c_46ec | - |
item.grantfulltext | open | - |
item.cerifentitytype | Publications | - |
顯示於: | 化學工程學系 |
檔案 | 描述 | 大小 | 格式 | |
---|---|---|---|---|
ntu-97-R95524082-1.pdf | 23.53 kB | Adobe PDF | 檢視/開啟 |
在 IR 系統中的文件,除了特別指名其著作權條款之外,均受到著作權保護,並且保留所有的權利。